Home

5R55S reverse servo

One possible cause of a delayed Reverse in this transmission can be a stuck Low/Reverse servo control valve, which is located in the Low/Reverse servo. The Low/Reverse servo control valve controls oil flow to apply the servo. When the valve sticks it cannot regulate and fills the servo very slowly, causing the delay

5r55s 5r55w transmission low/reverse bonded servo piston fits '02-'10 Rating Required Select Rating 1 star (worst) 2 stars 3 stars (average) 4 stars 5 stars (best) Nam 5R55W, 5R55S Low / Reverse Servo Piston [A46912A] - 5R55W, 5R55S Low / Reverse Bonded Servo Piston (2002-Up) 4L2Z-7D189A Ford, 5R55S, ReversePart# 575600. Transmission bands are thin steel bands that are anchored to a transmission's case and enable gear selection and action. Hydraulic transmission fluid provides the necessary force to activate these bands, which are also connected to servos. The servo mechanisms fill with the hydraulic transmission fluid in. Free Shipping on All Transmission Parts & Rebuild Kits Orders Over $35. Multiple warehouse locations in Las Vegas and the East Coast gets you transmission parts fast 6. The servo may slide out easily at this point but if not, if you take a #10 or 13/64th drill bit. The #10 is the best. Insert the smooth end into the bore, by putting a little side pressure on it, and slight prying pressure with a channel lock pliers, you can pull the servo out. Or you can wiggle it up and down and pull on it by hand

Sonnax Ford 5R55N/S/W Delayed Revers

5r55s 5r55w Transmission Low/Reverse Bonded Servo Piston

5R55W, 5R55S Reverse Servo Housing [D46914A] - 5R55S, 5R55W Reverse Servo D Cover Ring Type Housing (Replaces O-Ring Type) 1999-Up (9L2Z-7D036A Servo Assembly, (Used) Low / Reverse servo assembly (Servo Body Casting #1L2P-7B193 AC, Servo Cover Casting # XW4P-7D372 AA) (5R55S, 5R55W) (02-UP) img#910 Item #U46910A $49.8

Low / Reverse Servo & Band Make sure arrow on cover is aligned on servo body as shown. To remove cover align arrow on 5R55S Gear Ratios 1st 3.22 2nd 2.29 3rd 1,55 4th 1.00 5th 0.71 Rev. 3.07 5R55W Gear Ratios 1st 3.22 2nd 2.41 3rd 1,55 4th 1.00 5th 0.7 Borg Warner Overdrive, Intermediate, and Reverse Bands Bonded Overdrive & Intermediate Servos Overdrive & Intermediate Servo Bore Sleeves Superior 5R55W/N/S Shift Correction Kit Updated Superior K0105 Front Ring Gear Hub Snap Ring Ford Solenoid Pack High Quality Pump Bushing Extension Housing Bushing . Updates to the Transmissio

5R55S 5R55N 5R55W Low Reverse Borg Warner Sprag with 30 Lugs A46654 2000-2010 $ 58.00 Add to cart 5R55S 5R55N 5R55W Overdrive Servo 2.915 Inch X 2.915 Inch, Bonded Blue Dot A46902 16912G- Piston, 5R55S/5R55W Reverse Servo (Bonded) (1.655ID Cover) 2002-03 (Can Use 16912GA) 16964A: 16964A- Piston, 5R55N/5R55S/5R55W Forward Clutch (Bonded) (5.090OD) With Check Ball 1999-7/05 (This Has The Cushion # 853 Made Onto The Piston) 16907A

5R55W, 5R55S Low / Reverse Servo Piston [A46912A] - $24

  1. 2004 4.6 Mountaineer Transmission servo bore -5R55SCheck out My Amazon Auto Accessories Store! Lets make that Weekend job less Painful!.
  2. Ford 5R55W Overdrive Servo Piston 2.915 Single Lip Two O-Ring Cover 5R55S 5R55N 2000-On $35.23 5R55W Reverse Servo Piston 1.870 Single Lip 5R55S Automatic Transmission Lincoln Mercury Ford 02-O
  3. 23956A 5R55S 5R55W Transmission low reverse servo piston Bonded rubber piston, 2.998 diameter piston, 3.411 overall length, 1.869 barrel diamete
  4. ford 5r55s / 5r55w. model5r55s, 5r55w. new reverse servo piston. reverse servo piston with a. this is a new bonded rubber style transmission. this piston was used in 2004 - up units and retro fits 2002 - up

Considering the reverse issue, and the 50-60 kmph revving, I'd check the solenoid pack which controls the servos. They are known to go bad. 5r55s also are known for servo bore wear causing problems. There's also a part in the transmission pump that controls oil flow/pressure that can cause problems Ford 5R55N, 5R55W, 5R55S 5-Speed Automatic Transmission Reverse Servo Housing Filter Screen. (2000-2010). Be the First to Know Save our profile and keep up to date with our latest products

Sonnax Transmission parts for Ford 5R55S applications. Sonnax is an industry leader in the cutting edge design, manufacture and distribution of the highest quality products to the automotive aftermarket, commercial vehicle industries, and industrial sectors utilizing drivetrain technology Shift Pointers. The 5R55S/W transmission has been with us for a little more than a decade. Its common complaints include harsh forward engagement; harsh reverse engagement; delayed, harsh initial engagements; flares on the 3-4 shift; and bind-up on shifts. What has made this unit difficult to diagnose is the inability to comprehend fully how it. • For 5R55S and 5R55W units: OEM# 6L2Z-7034-CA * For 5R55N units: OEM# 4W4Z-7034-AB. 8-Lug Torque Converter Alignment Some 5R55 units use an 8-lug torque converter. In order to properly align the flex plate adapter, you will need to use a specific tool The Ford 5R55S and 5R55W transmissions are both very similar in design to the Ford 5R55N transmission and use electronic shift controls. The 5R55S/W are both Syncrounous units, as they do not use the intermediate clutch and intermediate sprag that the 5R55N incorporates. The Ford 5R55S and 5R55W transmissions wer Solarhome 5R55W 5R55N 5R55S Transmission Rebuild Kit for Ford Explorer 4.0L, 4.6L 2002-2010 Explorer Sport Trac 4.0L 2006-2010 Mustang 4.0L, 4.6L 2005-2010 Thunderbird 2003-2008 Lincoln Aviator. $249.00

SCSN 5R55S / 5R55W Transmission Solenoid Pack for Fo-rd Explorer Mustang Mercury Mountaineer Lincoln Aviator LS, Solenoid Block Pack Part#9L2Z-7G234-AA 9L2Z-7G391-AA 1.0 out of 5 stars 1 $124.99 $ 124 . 9 43210. Extension Housing Seal 5R55N. 40 ID x 60 OD x 10.70mm. 99-ON. 1. 25H. 43212. Extension Housing Seal 5R55S, 5R55W. 39 x 63 x 10 x 18.80mm

Ford, 5R55S, Reverse - TCI® Aut

Automatic Transmission Servo, High Performance, 3rd Gear, Billet Aluminum, for Ford 5R55S, Kit. Part Number: TCI-57600 SHIFT KIT® Valve Body Repair Kit All 5R55W, 5R55S, 5R55N 1999-o There is only a low/reverse servo, and no solenoid. You only have to ream the case to replace a bad bushing (due to irregular bore wear). There are other factors involved such as the servo, band, seals, internal clutch packs, sprag, and the valve body. Sometimes a bad shift fork or a shift rail in the transfer case could cause a no reverse issue Reverse Band Lever Kit for RWD Ford 5R55N/S/W Transtar Part Number: D46917-2 It is common for bands to brake at the strut cleat for the servo. Buy Now

5R55N 5R55W 5R55S Reverse Servo Housing Filter Screen

  1. Product Description. C3 - A4LD - 4R44E - 4R55E - 5R44E - 5R55E Used 100% Quality Inspected Rear (Reverse) Servo Piston Assembly 1974-on. This Is A Used 100% Quality Inspected Rear Servo Piston For These Automatic Transmissions, Ford Mercury Mazda Merkur. C3 1974 Thru 1987. A4LD 1985-95
  2. Automatic Transmission, 5R55S 82 steps to disassemble Automatic Transmission, 5R55S. Thursday, February 25, 2010. Automatic Transmission, Lincoln Ls. Transmission disassembly Special Tool(s) Remover, Input Shaft Oil Seal 308-375 Remove the reverse servo assembly. 18. CAUTION: Do not damage solenoid body connector pins..
  3. 5R55N / 5R55S / 5R55W RWD 5 Speed A 034 510 544 070 776 309 670 Input Shaft 590 650 674 868 223 883 630 022 555 336 337 O.Dr. Ring Gear O.Dr. Center Shaft Center 783 Support Interm. Band Direct Drum 128 108 148 876 232 231 882 602 Forward Clutch 592 235 582 622 Forward Planet 604 889 254 024 556 654 Reverse Band Reverse Drum Low Sprag 760 310.

Video:

2002-On units require a molded rubber forward clutch piston 58841W, molded rubber servo pistons, and a bonded separator plate 58107N (the Gasket Kit includes separate valve body gaskets. 2002 Ford Explorer 5R55W transmission had intermediate band and servo piston replaced. Shifted OK for 1-2 months, then developed 2-3 shift flare. Servo bores then rebushed. Helped, but still has flare.Shift seems delayed. Shifts better under hard acceleration. Posted by guytelko on Jan 25, 2011. Want Answer 0 5r55n 5r55s 5r55w transmission parts & rebuild kits. ford lincoln jaguar. sort by: 4r44e 4r55e 5r44e 5r55e 5r55n 5r55s 5r55w transmission stator rear bushing fits '95+ 5r55s 5r55w transmission low/reverse bonded servo piston fits '02-'10. ford. $32.77 $39.99. add to cart. compar 16964A- Piston, 5R55N/5R55S/5R55W Forward Clutch (Bonded) (5.090OD) With Check Ball 1999-7/05 (This Has The Cushion # 853 Made Onto The Piston) $34.23 Add to Car 5R55S slow engagement after fluid and filter service. The transmission had no problems before servicing. After servicing, it is slow to engage after coming to a stop or coasting down to a lower gear, there is a delay engaging. After stopping it needs to hit 1800 rpm to engage and does so harder than normal

Ford Transmissions: 5R55E- no reverse

SF-99 Servo Bore Repair System Master Kit, Ford C3, A4LD, 4R44E, 4R55E, and 5R55E type transmissions Part No. TOOL.112 Apply oil for both the overdrive and intermediate servos in Ford's A4LD and it's electronic four and fi ve speed successors, the 4R44E, 4R55E, and 5R55E, is routed through the hollow servo pins 56361J-01K 5R55N, 5R55S, 5R55W Overdrive & Intermediate Servo Pin Bore Sleeve Kit $ 62.00 Add to cart 5R55S 5R55N 5R55W Overdrive Servo 2.915 Inch X 2.915 Inch, Bonded Blue Dot A46902 A4LD 4R44E 4R55E 5R55E transmission rebuild kit with gaskets A4LD 4R44E 4R55E 5R55E transmission gasket A4LD 4R44E 4R55E 5R55E transmission reverse servo cover gaske 198 ill. description qty. year part no. ref no. ford 5r55n, 5r55s, 5r55w technical manuals 400h tech manual (5r55n).. 1 99-up 46400 27y0

Now you can reinstall the reverse servo and cover. Then torque the bolts to 80 inch lbs and then to 115 inch pounds. Next reinstall the manual detent return spring and make sure ur valve is installed correctly: Now you should be ready to plug the wires back in on the solenoids. than you may install the filter Low-Reverse Servo Cover Bolt 106 to 124 in-lb Center Support-to-Case Bolt 80 to 115 in-lb Separator Plate Bolt 53 to 71 in-lb TR Sensor 71 to 98 in-lb Valve Body-to-Case Bolt 71 to 98 in-lb Recommended Fluid & Capacities Mercon V (XT-5-QM) ATF 4R44E 2WD, 2.3L 9.9 Qts (9.4L) 4R44E 2WD, 3.0L 10.0 Qts (9.5L) 4R44E 4W

Ford Servo Bore Fix - Ford Lincoln Mercury Explorer

2002-2010 5R55S 4.0L 4X4 EXPLORER/MOUNTAINEER TRANSMISSION. $ 1,899.00. Before any upgrades, addons, and/or core charges. Our Process: All of our transmissions are fully remanufactured and are held to the highest and strictest industry standards. What this means to you is the fact you are getting a quality product that meets or exceeds the OEM. 2007 SC 2WD 4.0 with 5R55S, almost 125KMI. The bracket holding the shift cable has two bolts that needed to be removed in order to move the bracket out of the way of the one adjusting bolt. I put the truck on ramps so E-brake was set and blocked the wheel just in case. Painted one corner of the 4 point adjusting bolt and adjusted them to 120in. Automatic & Manual Transmission Replacement Parts. The transmission is tasked with converting your engine¿s output to the drive wheels. There are automatic transmissions that do the shifting for you or manual transmissions that put you in control. For manual transmission vehicles the clutch, flywheel, and pressure plate handle power transmission Valve Body Gasket set fits all 1995 and Up , 4R44E , 4R55E , 5R44E , 5R55E Models - See More Inf

Ford 5R55N, 5R55W, 5R55S Reverse Servo Housing Filter

5R55S 5R55W Valve Body And Solenoid Pack 02UP Ford Mustang Lincoln ls. Refurbished. 5.0 out of 5 stars. 5 product ratings. - 5R55S 5R55W Valve Body And Solenoid Pack 02UP Ford Mustang Lincoln ls. C $180.60. or Best Offer. +C $23.68 shipping estimate. from United States 5R55W (Ranger / Explorer) & 5R55S 5 SPEED 4WD WITH LOCK UP (Full Electronic Control) KITS Kit Overhaul Kit (Transtec).. 02-ON 1 5R55W.OHK01 Kit 175J Low/Reverse Servo Piston..... 02-ON 1 5R55W.SER01 SEALING RINGS 200A Stator Support Front to TC (Yellow Plastic Butt Joint). Ford 5R55S 5R55W - ATSG (Automatic Transmission Service Group) PDF. The Ford 5R55S and 5R55W transmissions are both very similar in design to the Ford 5R55N transmission and use electronic shift controls. The 5R55S/W are both Syncrounous units, as they do not use the intermediate clutch and intermediate sprag that the 5R55N incorporates

Ford 5R55N 5R55W 5R55S Reverse Servo Housing Filter Screen. Brand New. C $1.33. Top Rated Seller Top Rated Seller. Buy It Now. from United States. S p o n C Q s F o 2 B r H I e Q N 1 K d. 5R55N TRANSMISSION SOLENOID PACK FORD THUNDERBIRD , LINCOLN LS 99-up. Refurbished. 5.0 out of 5 stars 5R55S / 5R55W Shift Correction Kit. Mfg Retail: $128.45. Cost From Us: $109.00. You Save: $19.45. Fantastic Package to fix issues with these units - See More Info. 5R55S / 5R55W Shift Kit. Mfg Retail: $102.79. Cost From Us: $87.88. You Save: $14.91 RockAuto ships auto parts and body parts from over 300 manufacturers to customers' doors worldwide, all at warehouse prices. Easy to use parts catalog

NO REVERSE

No reverse, 5R55E- how can I tell if its bad o-rings bad

aftermarket - t9213sl, 5r55n 5r55s 5r55w, overdrive servo bore repair sleeve, bored, t9213sl, 1999-up. this part may fit: ford, jaguar, lincoln, & mercury . --- help reduce the return rate - if you are not 100% sure, send an inquiry including year, make, model, and engine size to ensure proper fitmen Reverse sometimes works but it struggles and needs a lot of throttle to get the truck moving. Parked the truck for a few weeks. Decided to take it out for a drive (truck needed to be boosted because of dead battery) out of habit I shifted to first and 2nd and then to drive with overdrive off after driving for a little bit I decided to try. The 5R55S/W is a Longitudal transmission. The 5R55S/W is a 5 speed automatic transmission, 4th gear is 1 to 1, it may deliver more torque but it is still only 1 gear overdrive. The final gear ratio is .75/1 in the W and .71/1 in the S, this is what separates the two units. The 5R55x utilizes three bands and two sets of planetaries to extrude.

5R55N, 5R55S, 5R55W Servo Pin Sleeve Kit [S46761A-2K5R55N,5R55S,5R55W Intermediate Servo Cover O-ring [IPN6

5r55s servo replacement - YouTub

But after I removed the pan I noticed that there was a torn screen inside one of the parts. A little googling shows that the screen is attached to the reverse servo. I don't see any obvious way to remove just the screen to replace it. I think if I want to replace it I have to replace the entire reverse servo? But the transmission overall runs fine 5R55S Transmissions for sale. We offer Used, Remanfactured, and Rebuilt 5R55S transmissions. Call to get a Quote Now (888)242-2605! Up to a 5 year Warranty, No Core Charge for 30 Days, Free Shipping in continental US Sonnax Master Servo Piston Kits. Sonnax master servo piston kits replace your piston and cover with no modifications needed to the case. These direct-fit kits are stronger to handle higher pressure and feature a no-leak, dual O-ring billet aluminum servo for superior sealing 5R55N,5R55S,5R55W. The 5R55E, though mechanically similar to the 4-speed 4R55E, was a new breed of electronically controlled automatic transmission with an additional forward gear. It was the first 5-speed automatic transmission to be employed by an American automaker. The 5R55E featured more precise computer controls (necessary to accommodate.

2002-2010 FORD 5R55S 5R55W INTERMEDIATE SERVO PISTON (PINK

2002-2010 ford 5r55w 5r55s, bonded overdrive servo piston2.575 x 2.900. sending a part number is required 5R55W Reverse Servo Piston 1.870 Single Lip 5R55S Automatic Transmission Lincoln Mercury Ford 02-On OPT Product Code: NTP-58827W. $33.13. Product Details. Ford OEM Equivalent: 4L2Z-7D189-AA, 4L2Z7D189AA 5R55W Reverse Servo Piston 1.870 Single Lip 5R55S Automatic Transmission Lincoln Mercury Ford 02-O 5r55n 5r55s 5r55w. part type: low/reverse servo piston. notes: bonded. years: 1999-up. brand: aftermarket. upc: 4l2z-7d189aa. quantity : call us today! sign up for our newsletter. about buffalo engine. buffalo engine components, inc. (bec) is a multi-faceted, family owned and operated corporation